Daily Bulletin


The Conversation

  • Written by John Page, Senior Lecturer with the School of Mechanical and Manufacturing Engineering, UNSW
The Conversation

The cracks found in three Qantas-owned Boeing 737s last week led to calls that it should ground its 33 aircraft with a similar service record.

Although the three planes have been grounded and will require complex repairs, the cracks – in a component called the pickle fork, which helps strengthen the join between the aircraft’s body and wing – do not threaten the plane’s airworthiness.

This makes it more of a threat to consumers’ confidence in Boeing and the airlines that fly its planes, rather than a direct risk to passenger safety, especially after the tragedies over a poorly thought out automatic control system installed on the Boeing 737 MAX 8.

Read more: Flights suspended and vital questions remain after second Boeing 737 MAX 8 crash within five months

More broadly, however, the pickle fork defects highlight a problem that aviation engineers have been contending with for decades: component fatigue.

The world’s first commercial jet airliner, the de Havilland Comet, launched in 1952 but suffered two near-identical crashes in 1953 in which the planes broke up shortly after takeoff, killing all on board. A third fatal breakup in 1954 triggered an investigation and threatened to end the era of mass air travel almost as soon as it had begun.

The crashes were all ultimately blamed on “fatigue failure”, caused by a concentration of stress in one of the passenger windows which resulted in a rapidly growing crack.

Almost any metal structure can potentially suffer fatigue failure, but the problem is that it is very hard to predict before it happens.

It begins at an “initiation area”, often at a random point in the component, from which a crack gradually grows each time the part is loaded. In the case of aircraft, the initiation area may be random, but from there the crack generally grows at a predictable rate each flight cycle.

One solution instituted after the Comet investigation was to subject all aircraft to regular inspections that can detect cracks early, and monitor their growth. When the damage becomes critical – that is, if a component shows an increased risk of failure before the next inspection – that part is repaired or replaced.

The current damage to the Qantas aircraft is a long way short of critical, as highlighted by the fact that Qantas has pointed out the next routine inspection was not due for at least seven months – or about 1,000 flights. This is normal practice under the official airworthiness directives for Boeing 737s.

Obviously, given the public relations considerations also involved, Qantas has nevertheless taken the three planes out of service immediately.

It might sound strange to say the cracks in the pickle forks aren’t a threat to the aircraft’s safety. Does that mean aircraft can just fly around with cracks in them?

Well, yes. Virtually all aircraft have cracks, and a monitored crack is much safer than a part that fails without warning. Bear in mind that all aircraft safety is reinforced by multiple layers of protection, and in the case of the pickle fork there are at least two such layers.

First, the pickle fork is secured with multiple bolts, so if one bolt should fail as a result of cracking, depending on the location there will be another five or six bolts still holding it in place.

Second, should the unthinkable occur and a pickle fork totally fail, there is still another “structural load path” that would maintain the strength of connection between the wing and body, so this would not affect the operation of the aircraft.

On this basis, it seems strange that the Australian Licensed Aircraft Engineers Association has called for the entire fleet to be grounded, especially given that this union has no official role in the grounding of aircraft. The Civil Aviation Safety Authority is the only agency in Australia with a legal obligation to make such a ruling, and has assured passengers it is unnecessary.

Aircraft maintenance procedures are drawn up by the manufacturer’s design engineering team. Before the aircraft obtains a permit to fly, the designer has to demonstrate to a regulator – in Boeing’s case, the US Federal Aviation Administration – that is has fully accounted for all airworthiness issues. This has to be proved by both engineering calculations and physical models. The result is an extensive maintenance manual for each aircraft model.

Read more: All Boeing 737 MAX flights grounded – and travellers could feel it in the hip pocket

Before each flight the aircraft must be demonstrated to conform to the maintenance manual, which is the role of the maintenance engineers who work directly for airlines. While the maintenance engineers’ union is right to bring any safety concerns or maintenance issues to the attention of the airline and possibly the regulator, only the regulator is in a position to rule on whether a fleet, or part of it, should be grounded.

Boeing and Qantas, and the many other airlines that fly 737s, are right to be concerned by this latest development because of the potential for it to harm them commercially. But while the cracked pickle forks will be giving executives headaches, passengers should rest easy in their seats.

Authors: John Page, Senior Lecturer with the School of Mechanical and Manufacturing Engineering, UNSW

Read more http://theconversation.com/should-you-worry-about-boeing-737s-only-if-you-run-an-airline-126268

Writers Wanted

Biden’s Senate majority doesn't just super-charge US climate action, it blazes a trail for Australia

arrow_forward

Disaster season is here — do you have a Resilience Action Plan? Here's how the small town of Tarnagulla built theirs

arrow_forward

Is your child anxious about starting school for the first time? Here's how you can help

arrow_forward

The Conversation
INTERWEBS DIGITAL AGENCY

Politics

Prime Minister's Remarks to Joint Party Room

PRIME MINISTER: Well, it is great to be back in the party room, the joint party room. It’s great to have everybody back here. It’s great to officially welcome Garth who joins us. Welcome, Garth...

Scott Morrison - avatar Scott Morrison

Prime Minister Interview with Ben Fordham, 2GB

BEN FORDHAM: Scott Morrison, good morning to you.    PRIME MINISTER: Good morning, Ben. How are you?    FORDHAM: Good. How many days have you got to go?   PRIME MINISTER: I've got another we...

Scott Morrison - avatar Scott Morrison

Prime Minister Interview with Kieran Gilbert, Sky News

KIERAN GILBERT: Kieran Gilbert here with you and the Prime Minister joins me. Prime Minister, thanks so much for your time.  PRIME MINISTER: G'day Kieran.  GILBERT: An assumption a vaccine is ...

Daily Bulletin - avatar Daily Bulletin

Business News

Getting Ready to Code? These Popular and Easy Programming Languages Can Get You Started

According to HOLP (History Encyclopedia of Programing Languages), there are more than 8,000 programming languages, some dating as far back as the 18th century. Although there might be as many pr...

News Co - avatar News Co

Avoid These Mistakes When Changing up Your Executive Career

Switching up industries is a valid move at any stage in your career, even if you’re an executive. Doing so at this stage can be a lot more intimidating, however, and it can be quite difficult know...

News Co - avatar News Co

4 Costly Mistake To Avoid When Subdividing Your Property

As a property developer or landowner, the first step in developing your land is subdividing it. You subdivide the property into several lots that you either rent, sell or award to shareholders. ...

News Co - avatar News Co



News Co Media Group

Content & Technology Connecting Global Audiences

More Information - Less Opinion